The Direct Bikes DB50QT-22 Spyder is a 50cc scooter featuring automatic transmission, electric and kick start, front disc brake, rear drum brake, digital instrumentation, LED lighting, under-seat storage, and meets road legal requirements. Below are key sections for safety, features, operation, maintenance, and troubleshooting.
Key components: 50cc 4-stroke engine, automatic CVT transmission, electric/kick start, front disc brake, digital speedometer, LED lights, storage compartment.
| Feature | Description |
|---|---|
| Engine | 50cc 4-stroke air-cooled |
| Transmission | Automatic CVT |
| Starting System | Electric and kick start |
| Brakes | Front disc, rear drum |
| Instrumentation | Digital speedometer with odometer |
| Lighting | LED headlight and taillight |
| Storage | Under-seat compartment |
| Fuel Capacity | 5 liters |
| Max Speed | 30 mph (road legal) |
| Weight | 85 kg |
Always wear appropriate safety gear and follow traffic laws.
WARNING! Never operate under influence of alcohol or drugs. Always use lights in low visibility conditions.
Handlebar controls: Right handle - throttle, front brake lever; Left handle - rear brake lever, light switches, horn, turn signals.
Instrument Panel: Speedometer, odometer, fuel gauge, indicator lights (turn signals, high beam, neutral).
Key positions: OFF, ON, LOCK. Storage compartment accessed via seat release (ignition key).
Perform these checks before every ride:
CAUTION! Do not ride if any safety issue is detected. Address problems immediately.
Starting procedure:
Operation Tips: Smooth throttle control, progressive braking, proper cornering technique.
| Interval | Service Required |
|---|---|
| Every 300 miles | Oil change, chain adjustment |
| Every 600 miles | Spark plug check, air filter clean |
| Every 1200 miles | Brake inspection, tire check |
| Every 2400 miles | CVT belt inspection, brake fluid |
| Annually | Full service check |
Oil Change: Use 10W-40 4-stroke motorcycle oil. Drain plug underneath engine.
Air Filter: Clean with compressed air every 600 miles, replace if damaged.
Chain: Maintain 20-30mm free play, lubricate regularly.
Tire Pressure: Front 28-30 PSI, Rear 30-32 PSI (check when cold).
For long-term storage:
Tip: Start and run engine monthly if possible.
| Symptom | Possible Cause | Corrective Action |
|---|---|---|
| Won't start | Fuel, spark, battery | Check fuel level, spark plug, battery charge |
| Poor performance | Air filter, carburetor | Clean air filter, check carburetor settings |
| Brakes weak | Worn pads, air in lines | Inspect pads, bleed brakes if needed |
| Electrical issues | Fuses, connections | Check fuses, clean battery terminals |
| Unusual noise | Chain, bearings | Lubricate chain, check wheel bearings |
Service: Contact authorized Direct Bikes dealer for major repairs.
Support: www.directbikes.net or customer service hotline